人気ブログランキング | 話題のタグを見る

BDP-80の修理

BDP-80の修理_a0022655_195449.jpg


かなり長い期間、完全放置しておりました。


最近、BDP-80の調子が悪く、ディスクローディングして再生開始すると電源が落ちるという現象に遭遇する率が高くなってしまいました。

たぶん、BDP-83などでも同様な症状で困っている方もいらっしゃるかもしれませんね。

本機はファンレスであるため、熱がこもるのでしょうね。
熱に弱い部品=電解コンデンサと相場は決まっております。
以前、本体分解した際にも中国製とおぼしき素性不明なものを多数使っていたので、きっと電源回路基板の電解コンデンサが不良になっているとアタリをつけて、修理することにしました。

以前と同様に、上蓋を外すところから作業は開始です。
サイドの左右2点ずつ、それから背面の4カ所を外して慎重にフタを斜め上に持ち上げて取り外します。

BDP-80の修理_a0022655_19274988.jpg


BDP-80の修理_a0022655_1927467.jpg


外した電解コンデンサは全部で7個です。最も損傷が酷いように見えたのは400V82uFのものです。
液漏れのような症状出ていました。使用電圧はAC100Vなので、耐圧低くて容量が大きいものを選ぶという選択肢も考えられましたが、無難なセンで同じものの国産品にリニューアルです。
10V470uFは16V470uFの105℃品に交換しました。こちらは外観上では問題なかったのですが、電源周りなので、リップル電流のストレスで容量経年変化が激しいと踏んでの交換です。


BDP-80の修理_a0022655_19275252.jpg


BDP-80の修理_a0022655_1921329.jpg


すべてのコンデンサは低インピーダンス品の国産メーカーのものにこだわっての交換ですが、予算的には1000円強で済みました。

それにしても、基板上の電解コンデンサはメーカー不明のものも複数混じっております。
ついでに交換にしては大仕事なので、見送りましたが(^_^;

なお、ディスクの再生が不安定の状態も続いていたので、事前にOPPOに質問メールをしておきました。
特にFOXのブルーレイディスクが途中でフリーズして、また再生するようなことが頻発しておりました。

メーカーであるOPPOからの回答メールは下記のとおりです。

Is the image freezing (you see a still image on your television) or is the image just dropping out? If the later, then try another HDMI cable, as a bad HDMI cable can cause these kind of errors.


Try connecting HDMI to a television directly if you are going through a receiver and see if the same thing occurs.


If the image is freezing, your laser head could just be dirty or otherwise obstructed.

You will remove the screws on the side (two on each side) and back of the player (5 screws). Remove the top cover of the player by lifting up and pulling the cover away from the player.

When you remove the top cover you will see the loader. The loader has two pieces of electrostatic tape and two screws (one on each side). Remove these.

On each side of the loader there are two black clips. Push on on one of the clips and pull up on the metal cover. You will hear a snap. Do the same for the clip on the same side as the one you just depressed. Repeat for the other side.

You can now safely remove the top of the loader and gain access to the servo. Now clean the laser head surface with a cotton swab and alcohol. Also clean the rubber spindle on the servo to make sure there is no hair or lint which can make the discs load off center.

Reverse the steps to put the player back together and try disc playback and see if the same errors persist.


Best Regards,

Customer Service
OPPO Digital, Inc.
162 Constitution Dr.
Menlo Park, CA 94025
Service@oppodigital.com
Tel: 650-961-1118
Fax: 650-961-1119


ここまで親切な回答をもらえるとは思ってもみませんでした。
せっかく分解したついでです。
ちゃんと手順を参考にしながら、レンズを露出させてクリーニングです。
元通りにしたつもりがネジが余ることはよくあるので、しっかりと組み立て直してください。

今のところ、非常に調子よく動作してくれるようになりました。

次機種?の導入が決まるまで、まだまだ頑張ってもらおうと思っております。
やはりUHD BD?
by takas1961 | 2016-05-11 07:00 | DVD/LD/BD

映画とスキーとR32に偏愛する日々を綴っています

by takas1961
S M T W T F S
1 2
3 4 5 6 7 8 9
10 11 12 13 14 15 16
17 18 19 20 21 22 23
24 25 26 27 28 29 30
31